Adam-D
Member
Registered: 11th May 02
Location: Cheshire
User status: Offline
|
wont start...
it was running in the donor car. / astra
now it does not in the corsa.
9 pin plug wireing is done.
im left with 3 wires spare from the c20xe loom
main live to c20xe loom is connected.
switch'd live to thin black wire on c20xe loom is connected.
fuel relay clicks on and off with ignition
but when turning over fuel pump does not run. ive bridged the pump and there does not seem to be spark either.
everything is connected that i can see.
im tired and had enuff.
any ideas would be aprreciated. 
|
craig55
Member
Registered: 12th Jun 10
Location: Bristol
User status: Offline
|
does the eml light come on the dash
|
Slugger1990
Member
Registered: 29th Nov 09
Location: Cumnock, East Ayrshire
User status: Offline
|
my guess would be something to do with the extra wires left over tbh
|
Slugger1990
Member
Registered: 29th Nov 09
Location: Cumnock, East Ayrshire
User status: Offline
|
or check crank sensor
|
corsa-vxr
Member
Registered: 15th Apr 11
Location: ayr
User status: Offline
|
crank sensor faulty maybe??
|
Kieran
Premium Member
Registered: 12th Sep 08
Location: Kent
User status: Offline
|
Need a extra earth? I had to add a earth to mine then started straight away.
|
john_c20xe
Member
Registered: 10th Feb 08
Location: Eastbourne, EastSussex
User status: Offline
|
quote:
Originally posted by Kieran
Need a extra earth? I had to add a earth to mine then started straight away.
i had the same problem, i used a jump lead from negative terminal to gearbox for a quick try and it worked. plus check the earths on the fuel rail
|
Adam-D
Member
Registered: 11th May 02
Location: Cheshire
User status: Offline
|
ok, only reaons i can think of is there is two brown and yellow wires. on the 9 pin plug area.
on my car one is disconnected. and its fine
on this car i didnt connect one. im guessing i might have connected the wrong one.
engine has two earths. manifold to slam panel
and gearbox to bulkhead.
i could add another wont hurt anything.
and the dash has had a digi dash fitted. i havent touched any of it of had it out.
no eml or i dont even know where it would be, or if its connected properly.
all other stuff lights up as it should i think/
|
Jed D
Member
Registered: 15th Mar 11
Location: Durham
User status: Offline
|
quote:
Originally posted by Kieran
Need a extra earth?
iv never had a xe but, id of said this ^
|
Generation
Member
Registered: 7th Jul 09
Location: Essex
User status: Offline
|
Checked at the rail for fuel?
theres an earth that bolts to the rail too
[Edited on 23-08-2011 by Generation]
|
Adam-D
Member
Registered: 11th May 02
Location: Cheshire
User status: Offline
|
there was no fuel at the rail.
but, i briged the pump. and the pump does run, rail fills up and reg sends it back at full pressure.
the loom was never removed from the engine when it was running fine.
so all stadard earth for the loom are connected. as they before.
[Edited on 23-08-2011 by Adam-D]
|
Generation
Member
Registered: 7th Jul 09
Location: Essex
User status: Offline
|
Does it happen to have an after marked immobilder/alarm?
|
Generation
Member
Registered: 7th Jul 09
Location: Essex
User status: Offline
|
Red/blue THICK goes fuel pump, unless you put these wrong way around?
|
Adam-D
Member
Registered: 11th May 02
Location: Cheshire
User status: Offline
|
i dont think it has a aftermarket alarm.
but will have to check that out.
ill check the red/blue aswell.
|
