3CorsaMeal
Member
Registered: 11th Apr 02
User status: Offline
|
the one thats wrapped around the pipe as it splits into two
can i take it off?
will it matter, as its crap, rusted and loose.
whats best way to get it off?
|
danny-corsa
Member
Registered: 15th Mar 05
Location: Warwickshire Drives: Astra GSi 16v
User status: Offline
|
the heat shield is normally there to stop something above it or near it getting too hot e,g: the pocket in front of the gear stick. if its ratteling take it off if not then leave it cos u could cause problems..... vauxhall don't just fit things for the sake of it
|
ed
Member
Registered: 10th Sep 03
User status: Offline
|
They do... Have you noticed the coat hangers on the B pillar trim? They are completely useless but they are still there
|
James R
Member
Registered: 4th Feb 03
Location: 205GTi16/306GTi16
User status: Offline
|
I find a balsa chisel and a big hammer is the most releiving way to remove them, but keep your face out the way, rust in the eye doesn't help.
Split the rolled seal edges then work down each side, done
|
Adam-D
Member
Registered: 11th May 02
Location: Cheshire
User status: Offline
|
rip it off
i unfolded the edges with a hammer and screwdriver then pulled it off
|
Matt.H
Member
Registered: 12th Mar 03
User status: Offline
|
i will be doing this soon aswell. car sounds crap with it vibrating all the time.
|
3CorsaMeal
Member
Registered: 11th Apr 02
User status: Offline
|
i hope its this vibrating, certainly sounds crap since fitting decat
|
Siberia
Member
Registered: 9th Oct 03
Location: Leprechaun Land Drives : Zafira GSI
User status: Offline
|
did you tighen the joint(not drugs) up? did you fit the sealing ring?
|
3CorsaMeal
Member
Registered: 11th Apr 02
User status: Offline
|
yeah, tighten it all very tight with lots of firegum stuff, it buzzes like a kazoo when i hit 5000rpm
|
Siberia
Member
Registered: 9th Oct 03
Location: Leprechaun Land Drives : Zafira GSI
User status: Offline
|
is there a casing around the cat? could be that tooo..........
|
James R
Member
Registered: 4th Feb 03
Location: 205GTi16/306GTi16
User status: Offline
|
quote: Originally posted by 3CorsaMeal
yeah, tighten it all very tight with lots of firegum stuff, it buzzes like a kazoo when i hit 5000rpm
The gasket ring is a dry seal, you shoudl go and buy a new one and not put any firegum, gun gum etc.. on it, just clean the faces with some scothbrite pad and put the new one on there, they only cost £1-2 from any tire/exhaust/qwikfit type place.
Sib's the CAT doesn't have a casing on it, it's gh*y.
|
PaulW
Member
Registered: 26th Jan 03
Location: Atherton, Greater Manchester
User status: Offline
|
quote: Originally posted by Adam-D
rip it off
i unfolded the edges with a hammer and screwdriver then pulled it off
My method was better... did it along with the rest of the system
|
Siberia
Member
Registered: 9th Oct 03
Location: Leprechaun Land Drives : Zafira GSI
User status: Offline
|
i fooking hate power tools they always try and hurt me
|
James R
Member
Registered: 4th Feb 03
Location: 205GTi16/306GTi16
User status: Offline
|
I stand corrected there is a cover on the CAT, you can see it there.
|
Siberia
Member
Registered: 9th Oct 03
Location: Leprechaun Land Drives : Zafira GSI
User status: Offline
|
quote: Originally posted by j1400
I stand corrected there is a cover on the CAT, you can see it there.
|
Siberia
Member
Registered: 9th Oct 03
Location: Leprechaun Land Drives : Zafira GSI
User status: Offline
|
nice extention lead paul... were did you buy that? i have to get one
|
PaulW
Member
Registered: 26th Jan 03
Location: Atherton, Greater Manchester
User status: Offline
|
quote: Originally posted by Siberia
nice extention lead paul... were did you buy that? i have to get one
Bought it from bodge-a-job
Address:
shed-at-top
the old mans house
down the way
aye
|
PaulW
Member
Registered: 26th Jan 03
Location: Atherton, Greater Manchester
User status: Offline
|
btw the wooden base is near 50 years old and also the powercable (the black bit) is from the late 70's
|
Siberia
Member
Registered: 9th Oct 03
Location: Leprechaun Land Drives : Zafira GSI
User status: Offline
|
antiques road show!!.. it might be worth something
|
PaulW
Member
Registered: 26th Jan 03
Location: Atherton, Greater Manchester
User status: Offline
|
worth something to who... the presenter or the undertaker sorting out my funeral for blowing myself up
best part... I could smell petrol when doing the grinding
|
AdiSRI
Member
Registered: 1st May 02
Location: Berkshire
User status: Offline
|
i cut mine off, stopped the rattling and the car hasnt burst into flames, its all good.
|