Haimsey
Premium Member
Registered: 8th May 05
Location: Nottingham Drives: Corsa B
User status: Offline
|
My car starts fine, but the EML doesnt go out once its on and idling.
It idles fine, but then it idles all lumpy and practically cuts out. If i rev it, sometimes the idle issue sorts itself out, but sometimes it doesnt.
Acceleration is fine and pulls fine. Just idling all funny.
The EML doesnt go out at all.
Any ideas on what to do? Or what it could be?
Im new to 1.6's so sorry if this has been asked loads before, couldnt find anything search-wise.
Thanks
Marc.
[Edited on 01-02-2009 by Haimsey]
Marcy Marc 
White Sport Progress Thread
|
gsi-killer
USER UNDER INVESTIGATION - DO NOT TRADE
Registered: 23rd Jan 09
Location: heathrow
User status: Offline
|
what air filter you got?
|
Richardhhha
Member
Registered: 29th Sep 07
Location: Croydon, Greater London
User status: Offline
|
try checking the thing for air leaks as its sounding like it is a little air leak thats causing this, what mods have been done?
|
Haimsey
Premium Member
Registered: 8th May 05
Location: Nottingham Drives: Corsa B
User status: Offline
|
Ive not had a proper look around it as ive only recently got it home.
But its got some stupid ass exhaust on it (not a decat) and some chavvy induction kit - which im swapping over today for my standard airbox off my old car.
Marcy Marc
White Sport Progress Thread
|
barneykarl
Member
Registered: 29th Jul 06
Location: Stevenage
User status: Offline
|
Find out what eml codes are stored, and check for air leaks around the throttle rubber sealing ring for starters.
|
scottboi
Member
Registered: 27th Feb 08
Location: maidstone kent
User status: Offline
|
do a paperclip test
[Edited on 25-01-2009 by scottboi]
|
sam 195
Member
Registered: 24th Jan 09
Location: leicester
User status: Offline
|
could be a leaky inlet manifold gasket or split vacuum pipe
|
tom_simes
Show Staff
Organiser: South Wales
Premium Member
Registered: 12th Jan 05
Location: Undy, Newport Drives: Skoda Octavia vRS estate
User status: Offline
|
Sorry I didn't text back yesterday mate, I was in Bristol at a mates and as I was writing my reply my phone battery died!
Anyway, the bit I did manage to write was "Unfortunately, it could be anything!"
and from looking at these posts, they seem to agree with me Marc. When mine was running strange, I changed my idle control valve, but I never had the EML on.
Mine is also beginning to run a little strange at the moment though, and I also suspect an airleak, somewhere in the inlet system or a vacuum pipe 
|
koopa89
Member
Registered: 29th Oct 07
Location: Sudbury, Suffolk
User status: Offline
|
mines having the same problem.. iv taken it to the local garage and they checked it over completely. there was nothing wrong with it apart from a slightly split vacuum pipe which they repaired. when they plugged it into the computer the only fault it came up with was engine managment, but it didnt specifically say what the problem was. therefore the garage said they couldn't fix it. so basically i have to take it to a vauxhall garage.
so if anyone can help id be thankful... i don't really fancy paying vaux ££££!
cheers
[Edited on 26-01-2009 by koopa89]
|
maxx16v
Member
Registered: 25th Dec 08
Location: Falkirk
User status: Offline
|
a blank cheque for vauxhall.......oooohhh holy C R A P ......lol
|
Haimsey
Premium Member
Registered: 8th May 05
Location: Nottingham Drives: Corsa B
User status: Offline
|
Just did a paper clip test and got this -
1405 Exhaust Gas Re-circulation (EGR) valve n/a
Would that cause a rough idle though 
Marcy Marc
White Sport Progress Thread
|
Haimsey
Premium Member
Registered: 8th May 05
Location: Nottingham Drives: Corsa B
User status: Offline
|
Any ideas where the EGR valve is on the X16XE?
Roughly how hard to fit?
Thanks.
Marcy Marc
White Sport Progress Thread
|
Haimsey
Premium Member
Registered: 8th May 05
Location: Nottingham Drives: Corsa B
User status: Offline
|
The light has gone out and not come back on now  WTF?
Marcy Marc
White Sport Progress Thread
|
tom_simes
Show Staff
Organiser: South Wales
Premium Member
Registered: 12th Jan 05
Location: Undy, Newport Drives: Skoda Octavia vRS estate
User status: Offline
|
quote:
Originally posted by Haimsey
The light has gone out and not come back on now WTF?
Typical EGR mate  Mine was on for approximately 200 miles - when I drove it about 400 yards to my garage to do the paperclip test, it didn't come on, and hasn't since
|
Haimsey
Premium Member
Registered: 8th May 05
Location: Nottingham Drives: Corsa B
User status: Offline
|
Ive done ~350 in it.
200 motorway miles back home when i first got it with my EML on
Should i replace it anways seeing as the garage is paying.
Marcy Marc
White Sport Progress Thread
|
jonakamad
Member
Registered: 27th Jan 09
Location: Swindon
User status: Offline
|
to get to the egr valve u have to remove battery and tay if removable then push the water bottle over wher the battery was and remove the loom runnin around that area the if u look under the inlet manifold u can just see it. its a bit of a fiddlie job but easy enough to do, while ur there u mite as well remove idle control valve n give it a clean just to make sure.
|
